Sugarcane Straw Availability, Quality, Recovery And Energy Use: A Literature Review

Sugarcane straw represents, under Brazilian conditions, approximately one third of the total primary energy of sugarcane in the field. Today, its use for energy is incipient and it is mostly wasted by either burning in the pre-harvest or left on the ground to decay. Besides its potential use as feedstock for energy production, there are several possible agronomic benefits of the straw blanket left on the ground such as soil protection against erosion, increase of soil organic carbon content, inhibition of weed growth, nutrient recycling and reduction of soil water losses, to name a few. The balance of the impacts and the economic and energetic value of the straw indicate that the amount of the straw left on the ground that could be considered optimal is dependent on the local conditions, agricultural practices, characteristics of the straw and intended final use. This work is meant to shed some light into this subject to help the understanding of the importance of the various impacts of the straw blanket on the ground, the availability and quality of the straw, the economics of straw recovery and use and the main criteria for determining the amount of straw that can be recovered for bioenergy or biofuels production. © 2013 Elsevier Ltd.531119Leal, M.R.L.V., The potential of sugarcane as an energy source Proceedings of the XXVI International Society of Sugar Cane Technologists (ISSCT) Congress, pp. 23-34. , July 31st to August 3rd, 2007, Durban, South AfricaBall-Coelho, B., Tiessen, H., Stewart, J.W.B., Salcedo, I.H., Sampaio, E.V.S.B., Residue management effects on sugarcane yield and soil properties in northeastern Brazil (1993) Agron J, 85, pp. 1004-1008Meier, E.A., Thorburn, P.J., Wegener, M.K., Basford, K.E., The availability of nitrogen from sugarcane trash on contrasting soils in the wet tropics of North Queensland (2006) Nutr Cycl Agroecosys, 75, pp. 101-114Sparovek, G., Schnug, E., Temporal erosion-induced soil degradation and yield loss (2001) Soil Sci Soc Am J, 65, pp. 1479-1486Dourado-Neto, D., Timm, L.C., Oliveira, J.C.M., Reichardt, K., Bacchi, O.O.S., Tominaga, T.T., State-space approach for the analysis of soil water content and temperature in a sugarcane crop (1999) Scientia Agricola, 56 (4), pp. 1215-1221Tominaga, T.T., Cássaro, F.A.M., Bacchi, O.O.S., Reichardt, K., Oliveira, J.C.M., Timm, L.C., Variability of soil water content and bulk density in a sugarcane field (2002) Aust J Soil Res, 40, pp. 604-614Graham, M.H., Haynes, R.J., Meyer, J.H., Changes in soil chemistry and aggregate stability induced by fertilizer applications, burning and trash retention on a long-term sugarcane experiment in South Africa (2002) Eur J Soil Sci, 53, pp. 589-598Cerri, C.C., Galdos, M.V., Maia, S.M.F., Bernoux, M., Feigl, B.J., Powlson, D., Effect of sugarcane harvesting systems on soil carbon stocks in Brazil: an examination of existing data (2011) Eur J Soil Sci, 62, pp. 23-28Hassuani, S.J., Leal, M.R.L.V., Macedo, I.C., Biomass power generation: sugarcane bagasse and trash (2005) Série Caminhos para Sustentabilidade, , PNUD-CTC, PiracicabaAtchison, J.E., Hettenhaus, J.R., (2004) Innovative methods for corn stover collecting, handling, storing and transporting, pp. p. 52. , National Renewable Energy Laboratory, Golden, Colorado, Report No. NREL/SR-510-33893Michelazzo, M.B., (2005) Análise de sensibilidade de seis sistemas de recolhimento do palhiço da cana-de-açúcar (Saccharum spp.), , Master's Thesis, Universidade Estadual de Campinas, CampinasBraunbeck, O.A., Neto, E.A., Logística do transporte de material-prima e resíduos da cana-de-açúcar (2010) Bioetanol de cana-de-açúcar: P&D para produtividade e sustentabilidade, , Blucher, São Paulo, L.A.B. Cortez (Ed.)(2007) CGEE - Centro de Gestão e Estudos Estratégicos. Estudo prospectivo de solo, clima e impacto ambiental para o cultiva da cana-de-açúcar e análise técnica/econÔmica para o uso do etanol como combustível a, , NIPE/Unicamp e Centro de Gestão e Estudos Estratégicos, CampinasSokhansanj, S., Mani, S., Turhollow, A., Kumar, A., Bransby, D., Lynd, L., Large-scale production, harvest and logistics of switchgrass (Panicum virgatum L.) - current technology and envisioning a mature technology (2009) Biofuel Bioprod Bior, 3, pp. 124-141Hess, J.R., Kenney, K.L., Ovard, L.P., Searcy, E.M., Wright, C.T., Commodity-scale production of an infrastructure-compatible bulk solid from herbaceous lignocellulosic biomass (2009) Uniform-format bioenergy feedstock supply system design report series, p. 176. , Idaho National Laboratory, Idaho Falls, Idaho, Report No. INL/EXT-09-17527Seabra, J.E.A., Macedo, I.C., Comparative analysis for power generation and ethanol production from sugarcane residual biomass in Brazil (2011) Energ Policy, 39, pp. 421-428Dias, M.O.S., Cunha, M.P., Jesus, C.D.F., Rocha, G.J.M., Pradella, J.G.C., Rossell, C.E.V., Second generation ethanol in Brazil: can it compete with electricity production? (2011) Bioresour Technol, 102, pp. 8964-8971Larson, E.D., Williams, R.H., Leal, M.R.L.V., A review of biomass integrated-gasifier/gas turbine combined cycle technology and its application in sugarcane industries, with an analysis for Cuba (2001) Energy Sustain Dev, 1, pp. 54-76Seabra, J.E.A., Tao, L., Chum, H.L., Macedo, I.C., A techno-economic evaluation of the effects of centralized cellulosic ethanol and co-products refinery options with sugarcane mill clustering (2010) Biomass Bioenerg, 34, pp. 1065-1078Andraski, B.J., Mueller, D.H., Daniel, T.C., Effects of tillage and rainfall simulation date on water and soil losses (1985) Soil Sci Soc Am J, 49, pp. 1512-1517Timm, L.C., Oliveira, J.C.M., Tominaga, T.T., Cássaro, F.A.M., Reichardt, K., Bacchi, O.O.S., Water balance of a sugarcane crop: quantitative and qualitative aspects of its measurement (2002) Revista Brasileira de Engenharia Agrícola e Ambiental, 6, pp. 57-62Hillel, D., (1998) Environmental soil physics, , Academic Press, San DiegoGraham, R.L., Nelson, R., Sheehan, J., Perlack, R.D., Wright, L.L., Current and potential U.S. corn stover supplies (2007) Agron J, 99, pp. 1-11Wilhelm, W.W., Johnson, J.M.F., Hatfield, J.L., Voorhees, W.B., Linden, D.R., Crop and soil productivity response to corn residue removal: a literature review (2004) Agron J, 96, pp. 1-17Wilhelm, W.W., Johnson, J.M.F., Karlen, D.L., Lightle, D.T., Corn stover to sustain soil organic carbon further constrains biomass supply (2007) Agron J, 99, pp. 1665-1667(2010) Renewable fuel standard program (RFS2) regulatory impact analysis, p. 1119. , United States Environmental Protection Agency, Washington, DC, Report No. EPA-420-R-10-006, US EPASheehan, J., Aden, A., Paustian, K., Killian, K., Brenner, J., Walsh, M., Energy and environmental aspects of using corn stover for fuel ethanol (2004) J Ind Ecol, 7 (3-4), pp. 117-146De Maria, I.C., Dechen, S.C.F., Perdas por erosão em cana-de-açúcar (1998) Sociedade dos Técnicos Açucareiros Alcooleiros do Brasil, 17, pp. 20-21Macedo, I.C., (2005) Sugar cane's energy - twelve studies on Brazilian sugar cane agribusiness and its sustainability, , Berlendis & Vertecchia, UNICA, São PauloIzidorio, R., Martins Filho, M.V., Marques Júnior, J., Souza, Z.M., Pereira, G.T., Perdas de nutrientes por erosão e sua distribuição espacial em área sob cana-de-açúcar (2005) Engenharia Agrícola, 25 (3), pp. 660-670Andrade, N.S.F., Martins Filho, M.V., Torres, J.L.R., Pereira, G.T., Marques Júnior, J., Impacto técnico e econÔmico das perdas de solo e nutrientes por erosão no cultivo da cana-de-açúcar (2011) Engenharia Agrícola, 31, pp. 539-550Chapman, L.S., Larsen, P.L., Jackson, J., Trash conservation increases cane yield in the Mackay district (2001) Proc S Afr Sug Technol, 23, pp. 176-184Scarpare, F.V., (2011) Simulação do crescimento da cana-de-açúcar pelo modelo agrohidrológico SWAP/WOFOST, , PhD Dissertation, Universidade de São Paulo, PiracicabaThorburn, P.J., Van Antwerpen, R., Meyer, J.H., Bezuidenhout, C.N., The impact of trash management on soil carbon and nitrogen: I modelling long-term experimental results in the South African sugar industry (2002) Proc S Afr Sug Technol, 76, pp. 260-268Shrivastava, A.K., Shrivastava, A.K., Solomon, S., Sustaining sugarcane productivity under depleting water resources (2011) Curr Sci, 101 (6), pp. 748-754Peres, J.G., Souza, C.F., Lavorenti, N.A., Avaliação dos efeitos da cobertura de palha de cana-de-açúcar na umidade e na perda de água do solo (2010) Eng Agríc, 30 (5), pp. 875-886Garcia, S.M., (2005) Mulching vertical e manejo da água em sistema de plantio direto, , PhD Dissertation, Universidade Federal de Santa Maria, Santa MariaHowell, T.A., Phene, C.J., Distribution of irrigation water from a low pressure lateral-moving irrigation system (1983) Trans ASAE, 26, pp. 1422-1429Meyer, J.H., van Antwerpen, R., Henry, P.C., Leibbrandt, N., Improved cane yield from vertical mulching under rainfed and irrigated cane conditions (1992) Proc South Afr Sugar Technologists Assoc, pp. 89-94Wood, A.W., Management of crop residues following green harvesting of sugarcane in north Queensland (1991) Soil Tillage Res, 20, pp. 69-85Canellas, L.P., Velloso, A.C.X., Marciano, C.R., Ramalho, J.F.G.P., Rumjanek, V.M., Rezende, C.E., Propriedades químicas de um cambissolo cultivado com cana-de-açúcar, com preservação do palhiço e adição de vinhaça por longo tempo (2003) R Bras Ci Solo, 27, pp. 935-944Razafimbelo, T., Barthes, B., Larre-Larrouy, M.C., De Luca, E.F., Laurent, J.Y., Cerri, C.C., Effect of sugarcane residue management (mulching versus burning) on organic matter in a clayey Oxisol from southern Brazil (2006) Agr Ecosyst Environ, 115, pp. 285-289Vallis, I., Parton, W.J., Keating, B.A., Wood, A.W., Simulation of the effects of trash and N fertilizer management on soil organic matter levels and yields of sugarcane (1996) Soil Till Res, 38, pp. 115-132Feller, C., Efeitos da colheita sem queima da cana-de-açúcar sobre a dinâmica do carbono e propriedades do solo , p. 150. , Final report Fapesp 2001(98/12648-3). Piracicaba, BrazilLuca, E.F., (2002) Matéria orgânica e atributos do solo em sistemas de colheita com e sem queima da cana-de-açúcar, , PhD Dissertation, Universidade de São Paulo, PiracicabaGaldos, M.V., Cerri, C.C., Cerri, C.E.P., Soil carbon stocks under burned and unburned sugarcane in Brazil (2009) Geoderma, 153, pp. 347-352Blair, G.J., Chapman, L., Whitbread, A.M., Ball-Coelho, B., Larsen, P., Tiessen, H., Soil carbon changes resulting from sugarcane trash management at two locations in Queensland, Australia, and in North-East Brasil (1998) Aust J Soil Res, 36, pp. 873-881Robertson, F., Sugarcane trash management: consequences for soil carbon and nitrogen - final report of the project nutrient cycling in relation to trash management (2003) CRC for sustainable sugar production 2003, , CRC Sugar Technical Publication, BSES & CRC Sugar, IndooroopillyGraham, M.H., Haynes, R.J., Zelles, L.E., Meyer, J.H., Long-term effects of green cane harvesting versus burning on the size and diversity of the soil microbial community (2001) Proc South Afr Sugar Technologists' Assoc, 75, pp. 228-234Six, J., Conant, R.T., Paul, E.A., Paustian, K., Stabilization mechanisms of soil organic matter: implications for C-saturation of soils (2002) Plant and Soil, 241, pp. 155-176Silver, W.L., Neff, J., McGroddy, M., Veldkamp, E., Keller, M., Cosme, R., Effects of soil texture on belowground carbon and nutrient storage in a lowland Amazonian Forest ecosystem (2000) Ecosystems, 3, pp. 193-209Hao, X., Kravchenko, A.N., Management practice effects on surface soil total carbon: differences along a textural gradient (2007) Agron J, 99, pp. 18-26Resende, A.S., Xavier, R.P., Oliveira, C., Urquiaga, S., Alves, B., Boddey, R.M., Long-term effects of pre-harvest burning and nitrogen and vinasse applications on yield of sugar cane and soil carbon and nitrogen stocks on a plantation in Pernambuco, N.E. Brazil (2006) Plant Soil, 281, pp. 339-351Cerri, C.C., Bernoux, M., Feller, C., Campos, D.C., De Luca, E.F., Eschenbrenner, V., (2004) Canne à sucre et sequestration du carbone, p. 15. , Academie d'Agriculture de FranceLavelle, P., Decaens, T., Aubert, M., Barot, S., Blouin, M., Bureau, F., Soil invertebrates and ecosystem services (2006) Eur J Soil Biol, 42, pp. S3-S15Wisniewski, C., Holtz, G.P., Decomposição da palhada e liberação de nitrogênio e fósforo numa rotação aveia-soja sob plantio direto (1997) Pesq Agropec Bras, 32 (11), pp. 1191-1197Macedo, N., Botelho, P.S.M., Ribeiro, L.D., Stupiello, J.J., Petri, J., Oliveira, P.F.M., (2002) Número e época de aplicações de inseticidas no controle de cigarrinha da raiz Mahanarva fimbriolata em cana-de-açúcar, , 19° Congresso Brasileiro de Entomologia, Sociedade Entomológica do Brasil, ManausSilva, J.R.V., Costa, N.V., Martins, D., Efeito da palhada de cultivares de cana-de-açúcar na emergência de Cyperus rotundus (2003) Planta Daninha, 21 (3), pp. 375-380Martins, D., Velini, E.D., Martins, C.C., Souza, L.S., Emergência em campo de dicotiledÔneas infestantes em solo coberto com palha de cana-de-açúcar (1999) Planta Daninha, 17 (1), pp. 151-16