Accessory device fixation for voice rehabilitation in laryngectomised patients

Summary In most patients with advanced or recurrent laryngeal or hypopharyngeal cancer, total laryngectomy is indicated. This means the loss of the three main laryngeal functions: phonation; respiration; and the prevention of aspiration during deglutition. Laryngectomy patients have various options to restore phonation such as an esophageal voice, an electrolaryngeal voice or a tracheo-esophageal voice with a shunt valve. In the latter case a silicone rubber shunt valve is placed in the tracheo-esophageal wall and phonation is generated when exhaled air is forced through the shunt valve to the esophagus and neopharynx. The EUREKA project “Newvoice” aims at improving the plight of laryngectomees by realizing several subprojects. The outcome of the project should be a market ready, voiceproducing shunt prosthesis, and new biofilm-resistant silicone rubber and soft tissue interfaces like tissue connectors, which enable hands-free control of an improved “new voice” and prevention of trachea irritation. The latter is the main subject of this thesis. Difficulties in the fixation of prostheses for voice rehabilitation after laryngectomy In Chapter 2 we reviewed the literature on fixation problems with shunt valves, tracheostoma valves and heat and moisture exchange (HME) filters. Despite 22 years of experience (at the time of publication) with the implantation of tracheoesophageal shunt valves and many improvements in the materials used and the design, problems still remain such as biofilm formation with subsequent leakage through the valve, the need for frequent and inconvenient replacements, fistula enlargement leading to leakage around the device and reduced fixation, and infections. The high financial cost of shunt valves is a drawback to their use worldwide. To enable hands-free speech, different types of tracheostoma valve (TSV) have been developed. These valves are fixed to the skin or to the tracheostoma by means of an intratracheal device. An HME filter is used to protect the airway and maintain physiological balance. Such devices are only suitable for a select group of patients as fixation to the skin or trachea can be a major problem. Speaking and coughing cause pressure increases, which often result in mucous leakage and disconnection of the valve and/or HME filter. As fixation of TSVs and HME filters is difficult, only a minority of patients uses the devices and benefit from hands-free speech. Animal models for tracheal research Preliminary research concerning tracheal reconstruction and fixation possibilities to the trachea and esophagus was necessary before prototypes were tested invivo. Tracheal research contains two main areas of interest: tracheal reconstruction and tracheal fixation. Tracheal reconstructions are aimed at rearranging or replacing parts of the tracheal tissue using implantation and transplantation techniques. The indications for tracheal reconstruction are numerous: obstructing tracheal tumors, trauma, post-intubation tissue reactions, etc. Although in past years much progress has been made, none of the new developed techniques have resulted in a large-scale clinical application for (near complete) trachea replacement. Tissue engineering is believed to be the technique that will provide a solution for reconstruction of tracheal defects. However, developing functional tracheal tissue from different cultured cell types is still a challenge. Tracheal fixation research is relatively new in the field and concentrates on solving fixation-related problems for laryngectomized patients. It was found that the animal models used for tracheal research vary widely and in most publications proper scientific arguments for animal selection are never mentioned. It showed that the choice of animal models is a multifactorial process in which non-scientific arguments tend to play a key role. In this chapter (3) the results of post-mortem investigations and information for biomaterials scientists about tracheal research and the animal models used were listed. Consequently, after design and production of tissue connector prototypes, animal experiments were designed. Goats were thought to be the best animal models for these purposes. The tracheostoma tissue connector (TS-TC) and tracheo-esophageal tissue connector (TE-TC) were reported separately. In vivo experiments with tracheostoma tissue connector prototypes In a goat model a tracheostoma was created and the prototypes were implanted. After 6 weeks of subcutaneous implantation, percutaneous screws were inserted. After twelve weeks, the experiment was terminated and the implants with the surrounding tissues were processed and examined histologically by means of light microscopy. The clinical appearance during weeks 7 to 12 varied from very poor to relatively good. Histologically, the implants showed a uniform inflammatory response. Titanium or silicone rubber rings surrounding the tracheostoma subcutaneously combined with polypropylene mesh failed to immobilize the skin and subcutaneous tissue sufficiently. As a consequence, the classical mechanism of percutaneous implant failure was demonstrated. Chapter 4 describes two prototypes and the subsequent histological analysis of the device-tissue explants. Experimental results of the tracheo-esophageal tissue connector for improved fixation of shunt valves in laryngectomized patients To solve the fixation related problems of the TE shunt valve, a TE-TC was devised to serve as an interface between the patient’s tissue (trachea and esophagus) and a shunt valve. The TE-TC was defined as a permucosal connection constructed from a titanium ring (filled with a silicon rubber plug) combined with polypropylene or titanium mesh. After implantation in adult goats for 12 weeks the implants were submitted to histological investigation. Firm implant fixation was achieved. In nearly all animals (18/19), no signs of infection of the implant was seen. In total 11/19 animals died before the end of the experiment due to complications not related to the implant. In a pilot experiment (n=2) it was found that implantation of a TETC including punction of the dorsal tracheal wall was technically feasible and postoperatively safe for the animals. The TE-TC was considered a device with potential in the solution for fixation-related problems in tracheo-esophageal shunt valve voice rehabilitation. Histological assessment of titanium and polypropylene fiber mesh with and without fibrin tissue glue Both TS-TC and the TE-TC were stabilized by tissue ingrowth in mesh. Polypropylene (PP) and titanium (Ti) mesh are well-known surgical implants that provoke a relative low foreign body reaction. Firm stabilization of the implant is important to prevent migration and subsequent failure of the operation. Fibrin tissue glues are commercially available adhesives and are widely accepted in the medical field for hemorrhage, surgical bleeding, support of wound healing, wound and tissue gluing, sealing and closure but also as anti-adhesive agent in certain applications. Objective of this study was to evaluate the additional histological effect of fibrin glue application combined with two different types of mesh. Six pieces mesh of each (Ti, Ti with glue, PP and PP with glue), were subcutaneously implanted for 3, 6 and 12 weeks. After excision, processing and staining, light microscopic analysis was performed on the coupes using subjective histological description and histomorphometry. Capsule quality, capsule thickness, interstitial quality and total score were calculated. The samples with glue and without glue were compared by means of analysis of variance (ANOVA) tests. No complications were observed. In general the glue remnants remained visible at 3 and 6 weeks of implantation, accompanied by an inflammatory reaction and macrophage activity. In general the Ti group scored higher than the PP group, which is in line with the literature. At 12 weeks all samples showed good tissue integration without evidence of glue. The samples with glue clearly demonstrated a prolonged inflammatory response and were surrounded by fibrous tissue capsules that were significantly thicker compared to the samples without glue (P