Natural lactic acid bacteria population of tropical grasses and their fermentation factor analysis of silage prepared with cellulase and inoculant

This document is the Accepted Manuscript version of the following article: Waroon Khota, Suradej Pholsen, David HIggs, and Yimin Cai, 'Natural lactic acid bacteria population of tropical grasses and their fermentation factor analysis of silage prepared with cellulase and inoculant', Journal of Dairy Science, Vol. 99 (12): 9768-9781, December 2016. The Version of Record is available online at: https://doi.org/10.3168/jds.2016-11180.Natural lactic acid bacteria (LAB) populations in tropical grasses and their fermentation characteristics on silage prepared with cellulase enzyme and LAB inoculants were studied. A commercial inoculant Lactobacillus plantarum Chikuso 1 (CH), a local selected strain Lactobacillus casei TH14 (TH14), and 2 cellulases, Acremonium cellulase (AC) and Maicelase (MC; Meiji Seika Pharma Co. Ltd., Tokyo, Japan), were used as additives to silage preparation with fresh and wilted (6 h) Guinea grass and Napier grass. Silage was prepared using a laboratory-scale fermentation system. Treatments were CH, TH14, AC at 0.01% fresh matter, AC 0.1%, MC 0.01%, MC 0.1%, CH+AC 0.01%, CH+AC 0.1%, CH+MC 0.01%, CH+MC 0.1%, TH14+AC 0.1%, TH14+AC 0.01%, TH14+MC 0.1%, and TH14+MC 0.01%. Microorganism counts of Guinea grass and Napier grass before ensiling were 102 LAB and 106 aerobic bacteria; these increased during wilting. Based on morphological and biochemical characteristics, and 16S rRNA gene sequence analysis, natural strains from both grasses were identified as L. plantarum, L. casei, Lactobacillus acidipiscis, Leuconostoc pseudomesenteroides, Leuconostoc garlicum, Weissella confusa, and Lactococcus lactis. Lactobacillus plantarum and L. casei are the dominant species and could grow at lower pH and produce more lactic acid than the other isolates. Crude protein and neutral detergent fiber were 5.8 and 83.7% of dry matter (DM) for Guinea grass, and 7.5 and 77.1% of DM for Napier grass. Guinea grass had a low level of water-soluble carbohydrates (0.39% of DM). Guinea grass silage treated with cellulase had a lower pH and higher lactic acid content than control and LAB treatments. The 0.1% AC and MC treatments had the best result for fermentation quality. All high water-soluble carbohydrate (2.38% DM) Napier grass silages showed good fermentation quality. Compared with control and LAB-inoculated silage, the cellulasetreated silages had significantly higher crude protein content and lower neutral detergent fiber and acid detergent fiber contents. The results confirmed that cellulase could improve tropical silage quality, inhibiting protein degradation and promoting fiber degradation. Key words: cellulase, fermentation factor, lactic acid bacteria, tropical silagePeer reviewedFinal Accepted Versio