Treatment of Textile Wastewater by Combining Biological Processes and Advanced Oxidation

Treatment of textile wastewater is challenging because the water contains toxic compounds that have low biodegradability. Dyes, detergents, surfactants, biocides and more are used to improve the textile process and to make the clothes resistant to physical, chemical and biological agents. New technologies have been developed in the last decades and in particular Advanced Oxidation Processes (AOPs) have shown considerable potential for treatment of industrial effluents. These processes however are expensive and full scale applications are still scarce. In addition, the complex oxidation chemistry transforms the pollutants into a very large number of degradation intermediates which may be even more toxic than the original compounds. This thesis presents a novel treatment approach where two AOPs, photo-Fenton oxidation and ozonation, are used after an anaerobic biofilm process for treatment of textile wastewater, azo dyes degradation and removal of toxicity. The biological treatment cleaves the azo bonds of the dyes and consumes the biodegradable compounds whereas the following advanced oxidation degrades the aromatic amines and other by-products that are recalcitrant to biological degradation. The approach that includes photo-Fenton oxidation resulted in higher reduction of chemical oxygen demand (COD) than that with ozonation when treating real textile wastewater. The latter however resulted in higher reduction of toxicity towards the bacteria Vibrio fischeri and the shrimp Artemia salina. Mutagenic effects were detected in the untreated and biologically treated effluent, but not after photo-Fenton oxidation and ozonation. Environmental impact and costs of the two treatment strategies, at the operating conditions used in this study, are high compared with the full-scale biological process used in the Netherlands, where the wastewater is actually treated. Substitution of artificial light with sunlight and upscaling would result in great improvements in terms of electricity requirements and ozone consumption hence would bring down the environmental impact to values that are comparable to the biological process, suggesting that full scale implementation can be achieved. Further research should look into combining this treatment approach with technologies that allow water and salt recovery and reuse, to make the textile industry more sustainable