Optimisation of working parameters for lactic acid bacteria and yeast recovery from table olive biofilms, preserving fruit integrity and reducing chloroplast recovery

10 Páqginas.-- 5 Figuras.-- 5 TablasThe study of the table olive biofilms is usually achieved using a stomacher which causes the physical rupture of pitted olives in an osmotic media but does not differentiate between those on the surface and inside the fruits. Besides, the high amount of eukaryotic DNA released from the vegetable cells makes the further molecular study of the detached microbiota complex. This work applies Response Surface Methodology, based on a D-optimal experimental design and glass beads, to recover lactic acid bacteria (LAB) and yeasts from the biofilm of fermented olives without crushing the flesh. The RSM showed that the best simultaneous results were obtained by shelling the olives, at 8 °C, with glass beads (6 mm diameter) in a 0.16 (w/w) bead/olive ratio for 15 min at 330–400 rpm. Its application recovered lower LAB (possibly because of excluding those in the flesh), but similar yeast counts to the stomacher. The metataxonomic analysis of total DNA from biofilms showed that the glass bead-based protocol reduced the chloroplast sequences and improved the genera assignation for bacteria (16S) and yeast (ITS). The new non-destructive procedure enhances biofilm studies and may allow validating table olives as a carrier of probiotic microorganisms.This research was funded through the TOBE project (RTI2018-100883-B-I00, MCIU/AEI/FEDER, UE). ELG thanks the Spanish Ministry of Science and Innovation for his FPI contract (PRE2019-087812). ABC thanks to the Junta de Andalucía for his contract (PAIDI2020- 00162).Peer reviewe