Hydrothermal co-liquefaction of microalgae biomass and coal

In this research, the objective was to investigate under the chosen liquefaction conditions whether co-liquefaction of coal and microalgae biomass as agglomerates does possess a distinct advantage over the individual liquefaction of microalgae and coal. This was initially done by preparing dry micro algal biomass, followed by the preparation of coal fines and finally coal-algae as agglomerates. The agglomerates were prepared by continuously adsorbing wet concentrated microalgae slurry/solution onto the dry coal fines in order to prepare different ratios of coal-algae agglomerate(s). Ultimate analysis of the starting material (coal fines and the microalgae) as well the agglomerates then followed. According to research, wet microalgae biomass has the potential of acting as a hydrogen donor. By preparing the agglomerates, the rationale was to promote hydrogen supply from the micro algal biomass that has high hydrogen content to the coal with lower hydrogen content. The resulting product was then expected to have fairly higher hydrogen content. However, this was not observed or evident from the elemental analysis results. The results (elemental composition) showed no difference between the agglomerates and the coal. Based on the observed ultimate analysis results, liquefaction experiments were conducted to determine whether hydrogen transfer and the expected synergistic effect between micro algal biomass and coal would occur. The crude oil product was recovered and simulated distillation technique was used for the characterization of the crude oil product. The results we in agreement that higher yields can be achieved during co-liquefaction as compared to the individual liquefaction. A possible synergistic effect that was investigated in this research existed. Liquefaction results provided evidence of higher yields recovery from the agglomerates compared to those of coal fines and microalgae biomass. Although there was higher recovery on the agglomerates, there appears to be a downward trend (decrease) in product recovery with higher loadings of micro algal biomass on to the coal. This means that higher loading of micro algal biomass tend to suppress liquefaction of coal, thus resulting in lower product recovery. While lower loadings tend to effectively facilitate the liquefaction of coal, thus proving that the proposed synergistic effect between the two does exist. Overall product recovery (yields) of the agglomerates is higher compared to the individual recovery of coal fines and microalgae biomass. This was followed by mass balancing to determine the overall conversion. Higher conversions were achieved on the agglomerates compared to coal. This could mean that microalgae have the potential to facilitate the liquefaction of coal and improve its conversion. The observed trend results in improved conversion as well as higher oil yields (simulated distillation results). Overall, the mass balancing provided insightful information regarding the coal-microalgae interaction based on the conversion, and this further corresponds or supports the simulated distillation results. This research paper provides evidence of the synergistic effect that exists between micro algal biomass and coal