Effect of dissolved oxygen and chemical oxygen demand to nitrogen ratios on the partial nitrification/denitrification process in moving bed biofilm reactors

Partial nitrification was reported to be technically feasible and economically favorable, especially for wastewater with high ammonium concentration or low C/N ratio. In this study, the effect of dissolved oxygen (DO) and influent ratio of chemical oxygen demand to nitrogen (COD/N) ratio on biological nitrogen removal from synthetic wastewater was investigated. Experiments were conducted in moving bed biofilm reactors (MBBRs) on partial nitrification process in pilot-plant configuration for 300 days. DO levels were changed from 0.04 to 0.12 and 0.42 to 3.4 mg/l in the anoxic (R1) and aerobic (R2) reactors, respectively. The optimum DO for partial nitrification was between 1-1.5 mg/l in the aerobic reactor (R2). Influent COD/N ratios between 20 and 2 g COD/g-N were tested by changing the nitrogen loading rate (NLR) supplied to the pilot plant. During operational conditions when the DO concentration in aerobic reactor was above 1 mg/l, near complete organic carbon removal occurred in the total MBBRs system. The effluent total nitrogen concentration in the operational conditions (1.7-2.1 mg O2/l and NH+ 4-N=35.7 mg N/l) was obtained in the range of 0.85-2 mg/l. The highest nitrite accumulation (50%- 52%) took place at the DO concentration of 1-1.5 mg/l and increased with decreasing COD/N ratio in aerobic reactor (R2). This study showed that the average nitrification rate at various COD/N ratios is about 0.96 gN/m2 per day while the maximum nitrification rate is about 2 gN/m2 per day at COD/N ratios lower than 6. The experimental COD/N ratio for denitrification was close to complete sum of NO2 - and NO3 - (NOx) removal efficiency (about 99%) at COD/N ratio equal 14 in the operational conditions in the anoxic reactor (R1)