Techno-economic analysis of a hybrid CO2 capture system for natural gas combined cycles with selective exhaust gas recirculation

© 2018 Elsevier Ltd This work analyses the implementation of CO 2 capture in natural gas combined cycle (NGCC) power plants using a hybrid system integrated by an amine scrubbing plant and a CO 2 selective membrane. In this configuration, the membrane unit operates at close to atmospheric pressure and it is used to selectively recycle CO 2 back to the inlet of the compressor, therefore increasing the CO 2 content of the flue gas entering the capture system. A novel integration between the amine capture plant and the selective membrane is analysed here, which aims at exploiting the benefits of both the parallel and series selective exhaust gas recirculation (S-EGR) existing options. The mass and energy balances performed on this system indicate that the new configuration generates a flue gas with a CO 2 -enhanced concentration of 18%vol., which leads to a decrease in the energy demand in the reboiler by 6% with respect to an amine scrubbing system coupled to a conventional NGCC plant without S-EGR. Moreover, a reduction of 77% is achieved in the gas flowrate fed to the absorber of the amine plant, thus significantly reducing its size and cost. The calculated net electrical efficiency of the plant is 50.3%, which is 0.5 net percentage points higher than that of a conventional NGCC with amine-based capture and slightly lower than that of a reference plant with exhaust gas recirculation (EGR). These values are dependent on the pressure drop associated with the membrane system, which has a large influence on the energy balance of the plant. Therefore, higher efficiency improvements can be achieved if membrane module designs with reduced pressure drop are used. A techno-economic evaluation reveals that the cost of the membrane system has a strong effect on the capital costs of the plant and thus, on the cost of electricity and the cost of CO 2 avoided. These values vary between $81.9 and $93.9 per MWh and $82.6 and $121.8 per tonne of CO 2 avoided, respectively, for the S-EGR cases studied at a reference capacity factor of 0.85. A sensitivity analysis shows that it is necessary to reduce the costs of the reference hybrid S-EGR system in order to make it competitive against current benchmark options. Therefore, further ongoing development towards membrane units with high CO 2 permeance, limited pressure drop and reduced costs is particularly interesting for the S-EGR system studied in this work. The obtained results also indicate the targeted values of these parameters that can make the cost of the S-EGR configuration to be below that of conventional systems with amine capture and EGR options for CO 2 capture in NGCC power plants under different scenarios