Characterization of livestock manures biochar and their effect on soil chemical properties and crop growth under glasshouse conditions

Biochar is being promoted as an amendment to improve soil properties, crop productivity, and carbon sequestration. In Africa, biochar adoption is hindered by production systems which include technology and feedstocks availability. However, little research has been published on the influence of biochar incorporation on soil chemical properties and early crop establishment. The aim of this study was to characterize biochar from cattle, goat, sheep and poultry kraal manures and their effect on soil properties and crop growth. This was guided by the following specific objectives, (i) to explore the mixed-farming system of Raymond Mhlaba Municipality on availability and utilization of livestock kraal manures (ii) to characterize biochar samples produced from cattle, goat, sheep and poultry kraal manures (iii) to determine the nutrient release patterns of biochars amended in a degraded soil (iv) to determine the effectiveness of converting manure to biochar and cattle manure on maize early development and, (v) to determine the effects of biochar type and application rate on early maize development. The farming system was surveyed to identify quantities of livestock manure, its availability and utilization for soil fertility amendment in cropping in the Raymond Mhlaba Municipality. The emerging results across all the villages revealed that, the mean livestock numbers were, 9.24±8.21 sheep, 9.37±8.15 goats, 7.95±7.66 cattle and 9.02±9.47 chickens. The findings revealed that 94 (82.4percent) of the respondents had access to cropland allocations in the form of outfields and homegardens. However, only 55 (48.2percent) of the respondents were currently cropping their fields. Maize was the most common crop grown followed by butternuts and potatoes. The application of manure by the respondents currently cropping their lands was only 40 (35.1percent) and the quantities used ranged from 210-1450 kg ha-1. The results further showed that the estimated total manure production was 2.9 t year-1, 0.82 t year-1, 0.04 t year-1, and 0.8 t year-1 from cattle, goats, chicken, and sheeps respectively. Drum retort method of slow pyrolysis at a temperature of 400°C was used to produce biochar from cattle, goat, sheep and poultry manure feedstocks. The biochar yields were 63percent, 72percent, 61percent and 83percent on a weight basis for the different feedstocks. The chemical properties of the biochar were significantly different from those of the manure from which they were made. Biochars that were high in Ca and K such as poultry manure biochar and sheep manure biochar indicated higher pH and electrical conductivity values. For instance, sheep manure biochar was (8.1 mS cm-1) and poultry manure biochar was (9.2 mS cm-1). The scanning electron microscopy (SEM) revealed that, the biochars had porous structures ranging from 1.23um to 5.23um in diameter which are important for water conductance and holding capacity. The target soil carbon level to determine the effects of biochar soil incorporation was 2percent and the soil had 0.7percent. Therefore, it was treated with four livestock manure biochars at application rates of 0; 53.2 t ha-1 (CMB); 48.1 t ha-1 (GMB); 50.7 t ha-1 (SMB); and 40.2 t ha-1 (PMB) based on their carbon content to supplement the soil carbon difference. The effect on soil pH was such that SMB increased to 6.44, PMB (6.45), CMB (6.54), and GMB (6.53) relative to the control which did not show any changes. An increase was also observed on Olsen P concentrations (mg P kg-1) which varied with biochar treatments: PMB (6.22), GMB (6.37), SMB (6.44) and CMB (6.44) and were significantly higher than the control. Ammonium-N(NH4+) concentrations (mg NH4+-N) were increased in biochar treatments but, no significant differences were obtained with sampling time. SMB released 7.95 mg kg-1, CMB 7.50 mg kg- 1, PMB 7.46 mg kg-1 and GMB 7.05 mg kg-1, compared to the control 3.23 mg kg-1. Maize growth in soil sampled from farmers fields in cultivation and abandoned treated with biochar without application of inorganic fertilizer did not differ with control (soil only) treatments. However, maize growth in soil treated with biochar and inorganic fertilizer was comparative to manure treatments. This resulted in a follow up study to elucidate the effects of biochar alone and was carried out with cattle, goat, sheep and poultry biochars at five application rates (0, 100, 200, 300, and 400 kg C ha-1) applied to a sandy loam and a clayey loam soil of the Oakleaf and Tukulu soil forms respectively. Post-harvest soil pH, electrical conductivity and Olsen P showed improvements in biochar treatments relative to the control. Improvements in the chemical parameters and plant growth increased simultaneously with biochar application rate. Maize growth was not affected by biochar application at different rates