COMPARISON OF THE EFFICACY OF THREE SANITIZERS WITH 20,000 PPM CALCIUM HYPOCHLORITE FOR INACTIVATION OF SALMONELLA ON ARTIFICIALLY CONTAMINATED ALFALFA SEEDS

This study evaluated the efficacy of three alternative sanitizers, acidified sodium chlorite (ASC, also known as Sanova), stabilized oxychloro-based sanitizer (SOC, also known as Germin-8-or), and Tsunami 100 in comparison with 20,000 ppm Ca(OCl)2 for treatment of alfalfa seeds artificially inoculated with Salmonella. Small-scale experiments were conducted to determine the best treatment conditions for each sanitizer and how the initial Salmonella contamination level on seeds or Salmonella type may have on the efficacy of the sanitizers. Large-scale studies were performed to evaluate the commercial applicability of these sanitizers. As a comparison, seeds were also treated with 20,000 ppm Ca(OCl)2 for 15 min. To determine the optimal treatment condition, ten g of seeds containing 103 CFU/g (seed lot 1) or 105 CFU/g (seed lot 2) of S. Typhimurium expressing green fluorescent protein was treated with different concentrations of ASC, SOC, and Tsunami 100 for different period of treatment time. Results showed that the efficacy of ASC and SOC increased with increasing concentrations (up to 1500 ppm) and treatment time (up to 3 h); however, the germination rates for seeds treated with > 1200 ppm of either sanitizer was 2.5 log units to an undetectable level, compared with the 1.1 log unit decrease observed in seeds treated with Ca(OCl)2. When seeds from seed lot 2 (5 log units) were treated with 800 ppm of ASC or SOC for 3 h, the level of Salmonella were reduced by 3.8 log units or >4.3 log units to an undetectable level, respectively, compared with the 2 log units decrease observed in seeds treated with Ca(OCl)2. Treatment with 80 ppm of Tsunami 100 from 10 min to 24 h kept the germination rate higher than 85% but only reduced the Salmonella count by 0 to 1.8 log units. Between two seed lots, results of ASC showed that sanitizer could reduce more pathogen when the seeds contained higher initial Salmonella level. Ten g of seeds containing 105 CFU/g of four-strain cocktail of Salmonella was treated with ASC and SOC by optimal treatment condition. SOC and ASC eliminated Salmonella number by 2.8 and 1.6 log units respectively, less effective compare with the treatment of seed lot 1. For large-scale runs, 1 kg of seeds spiked with 1 % (w/w) of inoculated seeds containing 105 CFU/g of S. Typhimurium was treated with SOC and ASC under optimal treatment conditions. Salmonella level in seeds treated with 800 ppm SOC or ASC for 3 h decreased by 3.9 or 3.6 log units, compared with a 3.3 log reduction in seeds treated with 20,000 ppm Ca(OCl)2. The stabilized oxychloro-based sanitizer may provide an alternative seed treatment method for sprout growers.M.S. in Food Safety and Technology, December 201