Experimental evaluation of the steady state and dynamic performance characteristics of the interactive units of a coal gasification process. Quarterly report, 27 December 1982-3 April 1983

A Test Plan Report has been prepared which details all the tests proposed for the 1983 operational season. One of these tests evaluates the thermal recycle mode which would be employed in a commercial configuration. In this mode, the condensate stream en route to the resaturator is passed back to the first gas cooler. The gas to liquid heat exchanger heats the condensate prior to resaturation. The analytical system simulation model, developed under this program, has been used to assess the operation of this mode and to select baseline conditions for the proposed test. Analysis of the data and results from tests conducted during the 1982 season has continued. In specific application, particularly power generation, the need exists to accommodate unanticipated contingency conditions. The response of the gasifier to such an occurrence was tested in 1982. Validation of the component models for the gasifier and the acid gas removal system has continued. Several enhancements to the gasifier model in the devolatilization zone are being added to increase accuracy. Improvements in the representation of the CO/sub 2/ absorption rate in the acid gas removal system model are being incorporated. A simplified combined cycle system model, integrated control system, and operator interface software modules are being installed on the PEF system data acquisition and control computers. This will permit system operation and model validation under a simulated end-use configuration. 15 figures, 3 tables