J Occup Environ Hyg

Development of an air quality monitoring network with high spatio-temporal resolution requires installation of a large number of air pollutant monitors. However, state-of-the-art monitors are costly and may not be compatible with wireless data logging systems. In this study, low-cost electro-chemical sensors manufactured by Alphasense Ltd. for detection of CO and oxidative gases (predominantly O| and NO|) were evaluated. The voltages from three oxidative gas sensors and three CO sensors were recorded every 2.5\ua0sec when exposed to controlled gas concentrations in a 0.125-m| acrylic glass chamber. Electro-chemical sensors for detection of oxidative gases demonstrated sensitivity to both NO| and O| with similar voltages recorded when exposed to equivalent environmental concentrations of NO| or O| gases, when evaluated separately. There was a strong linear relationship between the recorded voltages and target concentrations of oxidative gases (R| > 0.98) over a wide range of concentrations. Although a strong linear relationship was also observed for CO concentrations below 12\ua0ppm, a saturation effect was observed wherein the voltage only changes minimally for higher CO concentrations (12-50\ua0ppm). The nonlinear behavior of the CO sensors implied their unsuitability for environments where high CO concentrations are expected. Using a manufacturer-supplied shroud, sensors were tested at 2 different flow rates (0.25 and 0.5 Lpm) to mimic field calibration of the sensors with zero air and a span gas concentration (2\ua0ppm NO2\ua0or 15\ua0ppm CO). As with all electrochemical sensors, the tested devices were subject to drift with a bias up to 20% after 9 months of continuous operation. Alphasense CO sensors were found to be a proper choice for occupational and environmental CO monitoring with maximum concentration of 12\ua0ppm, especially due to the field-ready calibration capability. Alphasense oxidative gas sensors are usable only if it is valuable to know the sum of the NO| and O| concentrations.P30 ES005605/ES/NIEHS NIH HHS/United StatesR01 OH010533/OH/NIOSH CDC HHS/United States2019-05-29T00:00:00Z29083958PMC65410116337vault:3223