Higher-order dynamic response of composite sandwich panels with flexible core under simultaneous low-velocity impacts of multiple small masses

AbstractSmall mass impactors, such as runway debris and hailstones may result in a wave controlled local response, which is essentially independent of boundary conditions. The higher-order impact model of sandwich beams presented by Mijia and Pizhong [Mijia, Y., Pizhong, Q., 2005. Higher-order impact modeling of sandwich structures with flexible core. International Journal of Solids and Structures 42 (10), 5460–5490] is developed and enhanced to impact analysis of sandwich panels with transversely flexible cores. Therefore, an improved fully dynamic higher-order impact theory is developed to analyze the low-velocity impact dynamic of a system which consists of a composite sandwich panel with transversely flexible core and multiple small impactors with small masses. Impacts are assumed to occur normally and simultaneously over the top face-sheet with arbitrary different masses and initial velocities of impactors. The contact forces between the panel and the impactors are treated as the internal forces of the system. First shear deformation theory (FSDT) is used for the face-sheets while three-dimensional elasticity is used for the soft core. The fully dynamic effects of the core layer and the face-sheets are considered in this study. Contact area can be varied with contact duration. The results in multiple mass impacts over sandwich panels that are hitherto not reported in the literature are presented based on proposed improved higher-order sandwich plate theory (IHSAPT). Finally, for the case study of the single mass impact, the numerical results of the analysis have been compared either with the available experimental results or with some theoretical results. As no literature could be found on the impact of multiple impactors over sandwich panels, the present formulation is validated indirectly by comparing the response of two cases of double small masses and single small mass impacts. Also, in order to demonstrate the applicability of the validation, the analytical relation of minimum distance between two impactors is derived based on Olsson’s wave control principle in this paper