Effects of pumping on entomopathogenic nematodes and temperature increase within a spray system

Exposure to hydrodynamic stresses and increased temperature during hydraulic agitation within a spray system could cause permanent damage to biological pesticides during spray application. Damage to a benchmark biopesticide, entomopathogenic nematodes (EPNs), was measured after a single passage through three different pump types (centrifugal, diaphragm, and roller) at operating pressures up to 828 kPa. No mechanical damage to the EPNs due to passage through the pumps was observed. Separate tests evaluated the effect of pump recirculation on temperature increase of water within a laboratory spray system (56.8-L spray tank) and a conventional-scale spray system (1136-L spray tank). A constant volume of water (45.4 L) was recirculated through each pump at 15.1 L/min within the laboratory spray system. After 2 h, the temperature increase for the centrifugal pump was 33.6 degrees C, and for the diaphragm and roller pumps was 8.5 degrees C and 11.2 degrees C, respectively. The centrifugal pump was also evaluated within the conventional spray system, under both a constant (757 L) and reducing volume scenario, resulting in an average temperature increase of 3.2 degrees C and 6.5 degrees C, respectively, during the 3-h test period. When comparing the number of recirculations for each test, the rate of temperature increase was the same for the conventional spray, system (for both the constant and reducing volume scenarios), while for the laboratory spray system the temperature increased at a greater rate, suggesting that the volume capacity of the spray tank is the primary factor influencing the temperature increase. Results from this study indicate that thermal influences during pump recirculation could be more detrimental to EPNs than mechanical stress. Results show that extensive recirculation of the tank mix can cause considerable increases in the liquid temperature. Diaphragm and roller pumps (low-capacity pumps) are better suited for use with biopesticides compared to the centrifugal pump, which was found to contribute significant heat to the spray system