Biochemical characterisation of dairy yeasts and their application in cheese as anaerobic adjunct cultures : a thesis presented in partial fulfilment of the requirements for the degree of Doctor of Philosophy in Food Technology at Massey University, Palmerston North, New Zealand

Yeasts are traditionally used as part of the surface microflora in surface-ripened cheeses, where they contribute positively to the flavour of the cheese. The primary objective of this study was to investigate the potential of three dairy yeasts to provide attributes as adjuncts in anaerobically ripened cheeses. Geotrichum candidum (B9001), Yarrowia lipolytica (B9014) and Candida kefyr (B9006), obtained from the Fonterra Co-operative Group Ltd, Palmerston North, New Zealand, were studied. They showed diverse metabolic activities in laboratory media, which were influenced by the growth conditions. The metabolic activities of special interest were the lipase and proteinase activities and the production of volatile compounds, as these are important for cheese ripening and flavour development. Lipase activity (p-nitrophenyl butyrate assay) and proteinase activity (fluorescein isothiocyanate β-casein assay) were determined in three fractions prepared from yeast cultures and designated as extracellular fraction, washed-cell fraction and intracellular fraction. Lipase activity of G. candidum was detected only in the extracellular fraction and increased five fold when induced by safflower oil in a shake culture (0.16 µM/min/mL supernatant at 24 h). Lipase expression was delayed in static cultures. Y. lipolytica showed lipase activity in extracellular, washed-cell and intracellular fractions under all conditions. Static cultures in both glucose and safflower oil media showed higher lipase activity than shake cultures. The lipase activity of Y. lipolytica was higher in the late stationary phase than in the log phase under all conditions tested. The highest lipase activity was detected in a 192 h static culture grown in safflower oil medium (0.13 µM/min/mg dry cell weight, 0.3 µM/min/mg dry cell weight and 4.29 µM/min/mL supernatant in the intracellular, washed-cell and extracellular fractions respectively). C. kefyr did not show any lipase activity ( five fold; analysed by SPME-GC-MS) were produced in the cheeses made with yeast adjuncts. However, the concentration of total CLA (free plus esterified; analysed by GC-FID) did not increase although a higher concentration of free linoleic acid (> 10 fold), the substrate for CLA synthesis, was produced in the cheeses made with yeast adjuncts. A study of the formation of aromatic volatile compounds by C. kefyr in a medium containing L-phenylalanine (L-phe) showed that the yeast's ability to produce phenyl ethanol, phenyl ethyl acetate and benzaldehydc (analysed by SPME-GC-MS) was enhanced with an increase in the initial L-phe concentration (in the experimental range; analysed by enzymatic assay using phenylalanine ammonia lyase), but the yield was very low (20-27%). The initial concentration of glucose (in the experimental range; analysed by enzymatic assay using Peridochrom glucose reagent) did not affect the production of these aromatic volatile compounds. This study successfully showed that the yeasts G. candidum and Y. lipolytica, when used as anaerobic adjuncts, can influence the ripening and flavour development in Cheddar and washed-curd, dry-salted cheeses. The study also showed the capability of C. kefyr to produce aromatic volatile compounds from amino acid fermentation but the yields need to be increased by further manipulation of the medium components and the culture conditions before this capability can be used commercially